Search results

  1. W

    How to adjust transfer case?

    I don’t know which NP transfer case is in my 92 2500 but the shift rod needs to be shortened and I can’t see how to adjust it. It’s in two pieces and one piece looks like a pipe the other rod piece slides into. The knob only goes half way forward on the floor. I’m assuming when the automatic...
  2. W

    How I got the internal clutch to work on my 92 NV4500 swap

    When I was searching on how to work the new internal clutch on the 2005 NV4500 I swapped into my 92 3/4 ton I kept seeing the opinion that the master and slave cylinders should always match up, that is, have the same year etc. application. But I really did not want to have to go through all...
  3. W

    Hood won’t open

    When I pull on the cable inside the cab the hood doesn’t release. I replaced that cable a year ago, it was broken inside the cab, but the parts under the hood were fine. I oiled everything under the hood then. I’d take the grill off for a closer look but it seems to bolt up under the hood...
  4. W

    Looking for neutral safety switch wire

    On a automatic is the neutral safety switch on the ground circuit or the positive starter circuit? Since I got my 92 back from the shop that swapped my auto for a 5 speed manual the starter won’t turn. I don’t have a schematic for it. Some trucks switch the ground at the tranny, and I have a...
  5. W

    2005 NV4500 with internal slave in my 92

    I had a shop swap my automatic out for a NV4500 they rebuilt. Now I need to hook up the hydraulics. They put a internal slave in it. I’d like to use a 92 master cylinder. There’s another thread on here I was reading, but it didn’t end with any solution. One post said the 05 and 92 masters...
  6. W

    NV4500 swap question

    I think I’ve looked at every YouTube vid on swapping out an automatic for a manual tranny on a 88-98 GM truck but haven’t seen a good description of how to get the pedals hooked up. I saw one shot of the clutch bracket off, and little mention of the brake pedal, so Seems like the manual brake...
  7. W

    20 minute warmup on my 4L 80E

    Below about 30 degrees my 4L80E takes 20 minutes to warm up enough for it to move. Once it’s warmed up it works great. My Dodge automatic only takes 3 minutes. Could loose bands be the cause? I only have a few thousand on this truck so am getting a servicing done in a few weeks. Thanks
  8. W

    looking for a good radiator

    If anyone can recommend a source for a good quality radiator for my 92 Chevy 2500 with a 5.7 I would greatly appreciate it. I'd like to find one with a pretty thick core
  9. W

    How to check climate doors?

    I’m not getting any air out of my windshield vents, is there a way of checking the door to them without removing the dash? My blower is new and the evaporator is clean as new and I’ve got lots of air to the other vents. I thought about getting a new climate control until I saw the price. I...
  10. W

    Delete oil cooler?

    I've got a leaking oil filter adapter, and/or oil cooler lines, and am wondering if I should just delete the cooler. I can afford to do both, and can do it easy enough but wonder if it's that important to have the oil cooled and I like the simplicity of having the lines gone. If anybody has...
  11. W

    Confused by tranny diostick

    I posted about a big leak from my 4L80E, where I added a quart of fluid at 35 miles to get home on. Adding the fluid put the level half way between ‘hot’ and ‘cold’ zones on the stick. When I got home I immediately checked it and saw no fluid on the stick. Couple days later, without driving...
  12. W

    4L80E leak

    I have an all stock 92 3/4 ton and the 4L80E tranny is leaking 2 quarts of fluid n the first 35 miles, then just completely stops leaking at two quarts down. I haven’t driven it much since I got it but I think it does drive OK at two quarts down, not sure. It does shift fine when it’s low ir...
  13. W

    5.7 oil mystery

    I asked this question six months ago, so apologies for repeating it but I’m using a quart of oil every 60 miles and would like to get my 1992 Chevy pickup back on the road. It doesn’t smoke or leak oil, does have a little blow by, but not a lot. So one question I have is, if it were using that...
  14. W

    5.7 using oil, no smoke

    My 1992 5.7L uses a quart every 60 miles and doesn’t leak or smoke. I do see a little smoke when I take the oil filler cap off but it’s not much, and there’s no smoke out the tailpipe. I don’t think it’s leaking only on the road, because I’ve tried stopping along the road and checking for...
  15. W

    Massive oil leak sometimes

    I've got a 92 Chevy with a 5.7 auto. It leaks oil so bad I can hardly bring myself to get in it and drive it. It does not smoke at all ever out the tail pipe. But I can't figure out where the oil is coming from and most of the time it doesn't drip at all. But sometimes if I get off the...
  16. W

    How to post

    Please tell me how to post something. Thanks.
Top