Recent content by JavaMan

  1. JavaMan

    4l80e lost forward after being parked for months

    I got a 96 K2500 Suburban 145k miles, no forward movement, but can reverse. Worked great prior to being parked for months. So first a little history. Trans fluid was changed at 62k miles, medium darkness, then changed again at 114k miles, medium darkness. We started a vacation a few days later...
  2. JavaMan

    4l80e kicking back to 3rd then no up shift

    The slip code isn't always a death sentence. Mine was giving the slipping code multiple times. Just needed some valve body work, and it runs great, 12k miles. Sent from my SM-G965U using Tapatalk
  3. JavaMan

    Increase 93 4L80E shift points?

    I thought 5000 was the redline with those engines due to crank velocity or piston velocity? Sent from my SM-G965U using Tapatalk
  4. JavaMan

    Vortec 454 Heater Core Bypass

    You may have done this already, but I found pulling the air filter box out gave me a lot more working space around those hoses. Only took like 5 minutes to pull that box. Sent from my SM-G965U using Tapatalk
  5. JavaMan

    Vortec 454 Heater Core Bypass

    I know its 3/4 inch. Couple years ago I replaced the two T fittings, where it splits to feed front and rear heaters and the second one was the return from both. I bought the wrong size at first, so I made note that it is 3/4. Sent from my SM-G965U using Tapatalk
  6. JavaMan

    Which filter for a 1999 4L80E?

    I've used Wix 58836 filters in my 4l80e, that part comes with the nitrile gasket. Wix has another part without the gasket. Also, check that is says 17 bolt. The parts store websites show the 2500 coming with 4l60e and 4l80e, even with the 454 engine. You can't rely on their filtering. The...
  7. JavaMan

    4L80E Torque Converter

    I've had the same problem for a couple years. Mine went out in the summer on a trip through the desert. I put the selector in third, and it drives fine. I've hooked up the scanner and got nothing, even in the TCM scanner module. For me, 4th gear works fine when cold. Can feel the 4th shift as...
  8. JavaMan

    Eating fuel pumps

    Check if the return line from the FPR to tank is clear. A blocked return line would cause excessive pressure. Check voltage on the pump while running. A frayed cable would cause low voltage while pump is running but normal voltage under no load. Sent from my SM-G965U using Tapatalk
  9. JavaMan

    99 4l80e gauge

    Ma not be the best place, but I added a drain port to my pan, which has a 1/8 NPT whole, which is the same size as the sensor for my gauge. Just routed the wire up the firewall and under the dash. Sent from my SM-G965U using Tapatalk
  10. JavaMan

    Hot air entering cab

    I've been having issues with the AC not cooling well. Its a 96 Suburban K2500. But the pressures high and low are where they should be. I was checking to see if the blend door wasn't working right, I found hot engine air blowing into the cab right at the AC recirculation intake. Everything right...
  11. JavaMan

    Behind the bumper Hitch

    While that looks nice and clean, it would be a pain to deal with the hitch pin and safety chains. Many people would not like that, which would explain why its difficult to find the part. During safety check, you would verify the safety pin is holding the hitch pin in place. Doesn't look like...
  12. JavaMan

    '97 K1500 Suburban Fan Clutch Comparison

    That's helpful to know. I've noticed it being warm upfront while the kids are freezing in back a few times when we travel through the desert the past couple of years. On a side note. Anyone delt with fan replacements under warranty? I think I got a Hayden spring 2019, it's a severe duty...
  13. JavaMan

    Heater (rear) isolation valves.

    While I understand not wanting points of failure, pinching a hose is itself a point of failure, as the pinch point weakens the rubber hose. I've been towed twice now due to those plastic T connectors breaking. They don't like the summer heat. I've been looking for metal T's to replace them, but...
  14. JavaMan

    K3500 Gearing

    What I'm amazed by is that with all the pressure on MPG ratings over the decades that they still use excess fuel to cool anything. They added a DEF tank to diesels years ago. Why have they not added a water tank, inject water into the cylinders to help cool the engine. Some high MPG...
  15. JavaMan

    Brakes got soft

    Well, it fixed itself today. Either adding a little bit of brake fluid, just topping it from midway between min and max, or just sitting there for a few days. But the pedal feels normal again. Sent from my SM-G965U using Tapatalk
See more

Latest posts

Members online

Total: 1,135 (members: 43, guests: 1,092)

Forum statistics

Threads
64,335
Messages
1,391,502
Members
51,440
Latest member
lolxnico

Share this page

Top